Welding with Natural Gas and OxygenBy virtue of its triple bond, acetylene burns hotter than any other common hydrocarbon when mixed with oxygen, but it isn’t the only flame hot enough for welding.
Uncategorized
1
Posts
1
Posters
2
Views
-
Welding with Natural Gas and Oxygen
By virtue of its triple bond, acetylene burns hotter than any other common hydrocarbon when mixed with oxygen, but it isn’t the only flame hot enough for welding. With the assistance of a homemade oxygen concentrator, [Hyperspace Pirate] was able to make a natural gas torch that melts steel, even if welding with the torch remains difficult.
[Hyperspace Pirate] built his oxygen concentrator around a pressure-swing adsorption system, which uses two tanks of a molecular sieve to selectively adsorb and purge nitrogen, leaving behind mostly oxygen. [Hyperspace Pirate] used reverse-osmosis membrane casings as the tanks, solenoid valves to control gas flow, and an Arduino with some MOSFETs to control the timing. For fuel, he used a convenient source of natural gas, already installed in his garage: the water heater’s gas supply. Since the house’s meter regulates the gas down to a fairly low pressure, and the oxygen concentrator doesn’t produce high pressures, the torch didn’t need any inline regulators.
Inline check valves, on the other hand, were very much necessary, a mixture of oxygen and natural gas propagating back along the lines being undesirable for obvious reasons, and flashback arrestors would have been a good addition. [Hyperspace Pirate] built the torch itself out of copper tubing and needle valves, with a 0.9 mm MIG welder tip as the nozzle. Adjusting the gas mixture was mostly a matter of trial and error. With an oxygen-rich flame, it could cut thin metal decently well, but it tended to melt thick pieces more than it cut. On the other hand, even with a neutral flame, the water vapor in the exhaust oxidized steel, which made welding quite difficult, but not impossible.
The oxygen supply by itself was an entertaining tool, turning smoldering pieces of charcoal or steel wool violently incandescent. With the assistance of some steel wool, [Hyperspace Pirate] set a steel tube on fire. With a bit more oxygen, it would probably make an effective thermic lance. If you still want to do your welding with acetylene, he’s also made that before.
youtube.com/embed/7IkyVFxDQQw?…
Gli ultimi otto messaggi ricevuti dalla Federazione
-
Giuli spende trenta milioni nostri per un Caravaggio....meloni urla anche stavolta?
-
I enjoyed and appreciated reading this post.
"I realized almost immediately that GNU/Linux and FreeBSD were so similar they were completely different."
This right here.
My initial impression with #FreeBSD in 2006 was quite similar. Of course, #Linux back then was a much different beast than what it has evolved (mutated?) into today.
Had I not pursued Linux system administration as a career, I *probably* would have stuck with FreeBSD.
We can make all the technical comparisons between the two OSes all day long but what drove my interest and enthusiasm are (1) the documentation and (2) the community.
-
@peacelink ma non sono riuscite ad evitare di sbavare mentre lo dicevano
-
@stefano Don’t bother filing a bug report. They will act stupid. Probably they are stupid about it. They think it is a bug. Actually the author probably wrote a program he knew was not a solution to the problem but which he could do on deadline and which was good enough for his job at HP.
-
@stefano Here is something new for you to be upset about, though, which affects everyone, Linux, BSD, illumos alike. I have been upset about it for over 20 years.
Read ‘man 5 fonts-conf’ or whatever your equivalent is. Read it carefully under ‘FONT MATCHING’. What it says is that a font is not chosen as you wished, but instead RANDOMLY. You are only LUCKY if you get the font you wished.
And if you experiment long enough you will find this is true.
Fontconfig is unfixable and must be scrapped.
-
L'Ucraina ha sviluppato nuovi missili balistici FP-7, analoghi all'ATACMS, ma due volte meno costosi
I test si stanno muovendo verso una nuova fase, i missili saranno testati direttamente in attacchi in Russia
-
E in omaggio la concessione decennale per l'uso di un pezzo di bosco demaniale.
-
@quinta non solo lo fa, ma se ne vanta pure.
